Home / Porsche / Porsche 718 Boxster / Cayman
Porsche 718 Boxster / Cayman
2016–present (982) · 2.0L / 2.5L Flat-Four Turbo (direct injection) / 4.0L Flat-Six NA (GT4/GTS) · 7-speed PDK / 6-speed manual
The Porsche 718 (982, 2016+) uses a 2.0L or 2.5L turbocharged flat-four with direct injection — carbon buildup on intake valves at 60,000–80,000 km (walnut blast required). The GTS 4.0 and GT4 use a naturally-aspirated 4.0L flat-six (no direct injection, no carbon concern). PDK fluid every 60,000 km with Porsche-spec fluid. Mid-engine layout — no AWD, no PTM. Simpler drivetrain than Cayenne/Panamera.
All Topics
Porsche 718 Common Problems Malaysia — 982
718 982 top issues: 2.0L/2.5L flat-four direct injection carbon buildup at 60,000–80,000 km (walnut blast required), PDK shudder from neglected fluid, intermediate shaft bearing (IMS) — NOT an issue on 982 (only 986/987). Turbo intercooler condensation on 2.0L: water in intake at cold start is normal. GT4 4.0L NA: no carbon issue but check valve stem seals at high mileage.
Read guide →
💰Porsche 718 Repair Cost Malaysia 2025
718 Malaysia repair costs: engine oil (A40) RM 450–750, PDK fluid RM 700–1,100, carbon cleaning (2.0L/2.5L) RM 900–1,400, spark plugs RM 300–550, PIWIS diagnostic RM 200–350. Mid-engine = no PTM or front diff fluid. Annual maintenance budget: RM 2,500–4,500 — cheapest Porsche to maintain. GT4/GTS 4.0L: no walnut blast needed, lower annual cost.
Read guide →
📅Porsche 718 Service Schedule Malaysia
718 982: engine oil every 10,000 km (A40 spec, 5.5L 2.0L / 6.0L 2.5L). PDK fluid every 60,000 km. Rear diff every 40,000 km. Brake fluid every 2 years. Spark plugs every 60,000 km. Air filter every 20,000–30,000 km. Carbon cleaning at 60,000–80,000 km (2.0L/2.5L only). Annual PIWIS diagnostic. GT4/GTS 4.0L manual: gearbox oil every 60,000 km.
Read guide →
🛢️Porsche 718 Engine Oil A40 Spec Malaysia
718 2.0L flat-four: 5.5L capacity. 2.5L flat-four: 6.0L. Must use Porsche A40 spec (0W-40 or 5W-40 fully synthetic). Approved: Mobil 1 0W-40, Castrol Edge 0W-40, Shell Helix Ultra 0W-40. Change every 10,000 km. Turbo flat-four: oil quality critical for turbo shaft bearings. GT4 4.0L NA: same A40 spec, 8.5L capacity.
Read guide →
⚙️Porsche 718 PDK Fluid Malaysia
718 7-speed PDK: Porsche-approved fluid (Esso LT 71141 or equivalent) every 60,000 km. Shudder at low-speed manoeuvring = fluid degraded. Malaysia: RM 700–1,100. GT4/GTS 4.0L 6-speed manual: Porsche MTF spec gearbox oil every 60,000 km, RM 400–650. Manual gearbox in Malaysia heat: check for clutch slip from heat soak.
Read guide →
💨Porsche 718 Air Filter Malaysia
718 982: mid-engine intake behind passenger cabin — air filter every 20,000–30,000 km, RM 150–250. 2.5L Turbo S: dual intake filters, RM 280–420. GT4 4.0L: high-flow intake, OEM filter every 20,000 km. Dirty filter on turbocharged 718 reduces boost efficiency. Malaysia dust: inspect at every oil change.
Read guide →
🌡️Porsche 718 Coolant Malaysia
718 982: G13 coolant (pink/lilac) — do NOT mix with G11 or G12. Change every 4 years or 80,000 km. Mid-engine layout: rear-mounted radiator for engine; cabin HVAC uses front heat exchangers. Turbo intercooler has separate water cooling on 2.5L Turbo S — inspect both circuits. Malaysia cost RM 380–620.
Read guide →
🛑Porsche 718 Brake Pads Malaysia
718 standard front pads: 40,000–60,000 km. OEM RM 450–800/axle. Electronic rear caliper (EPB): PIWIS retraction required — never force with a C-clamp. GT4: larger calipers and pads (track use), more frequent replacement possible. PCCB optional on Boxster Spyder/GT4 RS — ceramic pads only.
Read guide →
⭕Porsche 718 Brake Disc Malaysia
718 standard steel: 340mm front. Replace with pads. Malaysia OEM RM 1,000–1,800/axle. GT4 RS: 408mm front steel or optional PCCB. PCCB ceramic: no replacement unless cracked — ceramic pads only (RM 2,500–5,000/axle for pads). Avoid hard braking when discs are cold — ceramic PCCB can crack under extreme thermal shock.
Read guide →
🔵Porsche 718 Brake Fluid Malaysia
DOT 4 LV — change every 2 years regardless of mileage. EPB electronic rear caliper: moisture causes piston corrosion and fault codes. GT4/GT4 RS track use: change annually — track braking generates extreme heat, degrading fluid rapidly. Malaysia cost RM 230–380.
Read guide →
🔋Porsche 718 Battery Replacement Malaysia — PIWIS AGM
718 982: AGM 70Ah battery (mid-engine cars: battery in front luggage compartment). PIWIS IBS registration mandatory after replacement — otherwise power management faults and PDK adaptation resets. Malaysia installed RM 800–1,300. Battery location: front frunk — easy access compared to Cayenne.
Read guide →
⚡Porsche 718 Alternator Malaysia
Smart alternator with IBS. 718 electrical load is moderate — no air suspension ECU, no PDCC. Main loads: PDK mechatronic, PASM, A/C compressor, PCM. Malaysia RM 1,100–2,200. PIWIS register after replacement. Convertible (Boxster): soft-top motor adds load — check for belt squealing at high electrical demand.
Read guide →
❄️Porsche 718 Air Conditioning Malaysia
718 uses R1234yf. Single-zone climate. Mid-engine heat soak: A/C evaporator placed away from engine — less heat contamination than front-engine cars. Compressor RM 1,800–3,500. Cabin filter every 15,000 km. Boxster soft-top: check roof seals annually — water ingress damages A/C electronics under carpet.
Read guide →
🌬️Porsche 718 Cabin Filter Malaysia
718 982: cabin filter behind glovebox. Replace every 15,000 km. Activated-carbon filter RM 150–280. Mid-engine: engine hot air doesn't flow through cabin — cabin air quality generally better than Cayenne. Malaysia haze season: upgrade to activated-carbon type.
Read guide →
🔵Porsche 718 Tyre Guide Malaysia
718 Boxster/Cayman standard: 235/40 R19 front, 265/40 R19 rear (staggered — cannot rotate). GTS 4.0: 235/35 R20 front, 265/35 R20 rear. GT4 RS: 245/35 R20 front, 305/30 R20 rear — track-width tyres. Malaysia cost: RM 500–1,100 each. TPMS reset via PIWIS after every change. RWD: rear tyres wear faster.
Read guide →
🎯Porsche 718 Wheel Alignment Malaysia
4-wheel alignment after every tyre change or kerb strike. 718 mid-engine: aggressive camber settings especially GT4. PASM: alignment at reference ride height. GT4 RS: track alignment possible with adjustable geometry — specify road or track use. Malaysia standard RM 160–300; GT4 specialist setup RM 350–600.
Read guide →
✨Porsche 718 Spark Plugs Malaysia
718 2.0L flat-four: 4 iridium plugs every 60,000 km, RM 300–500. 2.5L Turbo S: 4 iridium plugs same interval, RM 320–520. GT4 4.0L flat-six: 6 iridium plugs, RM 450–750. Check ignition coils at the same service. Only OEM or Bosch/NGK-approved equivalent — aftermarket plugs cause misfires on turbocharged engines.
Read guide →
⛓️Porsche 718 Timing Chain Malaysia
718 982 flat-four: timing chain — no belt replacement. Low risk with regular A40 oil changes every 10,000 km. Cold-start rattle = investigate tensioner immediately. GT4 4.0L flat-six: also timing chain, same low risk. The 982 engine has better chain reputation than the 987.1 2.7L/3.4L units.
Read guide →
🔧Porsche 718 Carbon Cleaning Malaysia
718 2.0L and 2.5L: direct injection — no port injection to clean valves. Carbon on intake valves at 60,000–80,000 km: rough cold idle, hesitation, reduced power. Walnut blast: 4-cylinder smaller intake, RM 900–1,400. GT4 4.0L NA flat-six: port injection — no carbon concern. GTS 4.0L also port-injected: no walnut blast needed.
Read guide →
🔩Porsche 718 Engine Mount Malaysia
718 mid-engine: rear engine mounts + front crossmember mounts. Replace at 80,000–120,000 km. Signs: vibration through seat at idle, clunk on acceleration or deceleration. Mid-engine layout means mounts bear more torque reaction. Malaysia RM 700–1,400/pair. GT4/GT4 RS: stiffer sport mounts — more NVH but longer life.
Read guide →
🚗Porsche 718 Suspension Malaysia — PASM
718 uses coil springs (no air suspension) — lower running cost vs Cayenne/Panamera. PASM adaptive dampers optional — failure at 100,000+ km (RM 800–1,600/shock). Front MacPherson, rear multi-link. Malaysia potholes: front lower arm bushings at 60,000–80,000 km. GT4 RS: adjustable coilover suspension — set up for road, not maximum track negative camber.
Read guide →
💻Porsche 718 PIWIS Diagnostic Malaysia
PIWIS II/III mandatory for 718 982. Generic OBD misses: PDK adaptation data, PASM calibration, EPB retraction, battery IBS registration, tyre pressure calibration. GT4 RS: additional active aero (RFBA) diagnostics only via PIWIS. Malaysia PIWIS diagnostic RM 200–350.
Read guide →
🔔Porsche 718 Service Indicator Reset Malaysia
Service indicator reset via PIWIS or PCM menu after every oil change. Tracks engine oil and vehicle inspection intervals. PDK fluid, diff oil, and manual gearbox oil are NOT tracked — maintain at 60,000 km calendar intervals. Annual PIWIS health check recommended for PDK adaptation monitoring.
Read guide →
💧Porsche 718 Oil Leak Malaysia
718 flat-four turbo oil leaks: valve cover gasket, turbo oil feed line at 70,000+ km. Mid-engine layout: oil leaks visible as smoke or burning smell from engine lid area — not always visible underneath. RMS (rear main seal): less common than 911 but possible at 100,000+ km. Malaysia repair RM 500–2,000.
Read guide →
🔄Porsche 718 Differential Fluid Malaysia
718 RWD: rear differential only — every 40,000 km (Porsche GL-5 75W-90). No front diff, no PTM — simpler than Cayenne. PDK models: PDK fluid separate from diff. Manual GT4: manual gearbox oil (Porsche MTF spec) every 60,000 km. Malaysia rear diff service RM 300–500.
Read guide →
⛽Porsche 718 Fuel Economy Malaysia
718 2.0L Boxster city: 11–14 L/100km; highway: 8–10 L/100km. 2.5L GTS city: 12–16 L/100km; highway: 9–12 L/100km. GT4 4.0L city: 14–18 L/100km (NA, heavier throttle foot). Normal mode with A/C: most efficient. Sport mode: 20–30% higher. Cylinder deactivation on 2.0L: reduces highway consumption by 10–15%.
Read guide →
📈Porsche 718 Resale Value Malaysia
718 Boxster/Cayman: 40–55% depreciation in 5 years — no air suspension worry improves residual vs Cayenne. GT4 and GT4 RS: 20–35% depreciation (strong demand from driving enthusiasts). Manual variants worldwide hold best value. Malaysia 718 market: small but passionate — clean service history essential. GTS 4.0L manual is the value sweet spot.
Read guide →
✅Buying a Used Porsche 718 Malaysia — Checklist
Used 718 checklist: PIWIS scan for PDK fault codes and adaptation count. Cold start idle — carbon buildup test (rough idle = walnut blast needed). Oil level + condition. Turbo intercooler: check for oil contamination (sign of turbo seal failure). Boxster soft-top: operate full cycle, check for water stains on carpet. Service history with A40 oil records.
Read guide →
📖Porsche 718 vs 981 Boxster/Cayman — Malaysia Guide
981 (2012–2016): 2.7L/3.4L naturally-aspirated flat-six — no direct injection (no carbon), smoother power. IMS fixed vs 986/987. 982 718 (2016+): 2.0L/2.5L turbo flat-four — more torque, slightly less character, carbon concern. GT4 982: 4.0L flat-six (from 992 GT3) — no carbon, best driver's car. Malaysia buying: 982 GTS 4.0L or GT4 if budget allows; 982 2.0L for daily use.
Read guide →
⛽Porsche 718 Fuel Pump Malaysia
718 flat-four: in-tank low-pressure pump + HPFP piezoelectric. RON97 minimum — RON95 shortens HPFP life. Symptoms: hesitation at high rpm, hard start.
Read guide →
🔧Porsche 718 Fuel Injector Malaysia
718 flat-four uses direct injection — carbon deposits on injector tips at 60,000–80,000 km. Tight engine bay makes access harder. Ultrasonic cleaning or replacement at specialist.
Read guide →
🌡️Porsche 718 Radiator Malaysia
Compact front-mount aluminum radiator. Flat-four turbo runs hot under track use. Coolant flush every 4 years. Plastic end tanks can crack at high mileage — inspect at service.
Read guide →
🌡️Porsche 718 Thermostat Malaysia
Map-controlled thermostat — varies coolant temp by load. Failure: slow warmup (stuck open) or overheating (stuck closed). PIWIS can read coolant temp pattern. Replace at first sign of temp irregularity.
Read guide →
⚠️Porsche 718 Head Gasket Malaysia
Head gasket failure is rare on the 718 flat-four if coolant is maintained. Oil seal leaks (cam cover) are far more common. Monitor coolant level monthly. Overheating = do not continue driving.
Read guide →
🔩Porsche 718 CV Joint Malaysia
718 RWD: rear halfshaft CV joints — inner and outer. Boot inspection at every service. Hard acceleration with worn inner joint causes vibration. Boxster roadster: boots more exposed to road debris.
Read guide →
🪟Porsche 718 Window Regulator Malaysia
718 coupe/roadster: standard electric regulators. Boxster soft-top window mechanism is separate from regulator — ensure seal is watertight. Coupe mechanism robust and rarely fails before 100k km.
Read guide →
🔴Porsche 718 Check Engine Light Malaysia
PIWIS III required for accurate diagnosis — generic OBD misses Porsche-specific codes. Common causes: DI carbon lean codes (P0171), O2 sensor, PDK adaptation fault, MAF. Do not ignore — 718 flat-four has tight tolerances.
Read guide →
🚨Porsche 718 ABS Warning Light Malaysia
Wheel speed sensor fouled or hub bearing worn — most common cause. PIWIS scan for PSM/ABS module codes. PSCB ceramic brakes (if fitted): ceramic-specific sensor. Rear hub bearing wear common on spirited drivers.
Read guide →
📋Porsche 718 100K Service Malaysia
Major 100,000 km service: 4 NGK/Bosch spark plugs, PDK fluid flush, coolant HOAT, brake fluid (every 2 years), air filter, cabin filter. Inspect timing chain tensioner and HPFP cam follower. PIWIS adaptation reset.
Read guide →
📄Porsche 718 Insurance Malaysia
718 sports car: agreed value policy strongly recommended — market value depreciates and standard market value policies can under-insure. Comprehensive essential. GT4/GTS variants: higher premium. Consult specialist sports car insurer.
Read guide →
💰Porsche 718 Spare Parts Malaysia
OEM parts from Sime Darby Auto Performance (SDAP). PDK fluid spec shared with 911 — savings on fluid. Flat-four engine parts specific to 718 — limited aftermarket. Filters and wear parts: Mahle/Bosch available. Contact workshop for current pricing.
Read guide →
✅Porsche 718 Puspakom Guide Malaysia
B5/B7 inspection required for ownership transfer or >5 years. Ensure all LED lights functional. Sports exhaust: confirm catalytic converter retained — decat fails emissions. Ride height: normal road height for inspection.
Read guide →
💧Porsche 718 Cam Cover Seals Malaysia
718 flat-four: horizontal cam cover seals accessible from above. Oil seepage typical at 80,000–100,000 km. Oil smell from engine bay after parking. Porsche uses RTV sealant + gasket — specialist recommended.
Read guide →
🔧Porsche 718 Throttle Body Cleaning Malaysia
Direct injection flat-four: carbon accumulates on throttle body and intake manifold at 60,000 km. Symptoms: rough idle, hesitation at low speed. Throttle body service + walnut blast for intake valves every 60,000 km.
Read guide →
💡Porsche 718 Headlight Malaysia
982 (2016+): LED headlights standard. GTS/GT4: adaptive cornering lights. PDLS available on options. Matrix LED upgrade possible on equipped variants. Ensure any aftermarket LED matches projector housing spec.
Read guide →
🔄Porsche 718 Tyre Rotation Malaysia
IMPORTANT: Most 718 variants use staggered fitment (wider rear tyres e.g. 265/35R20 rear vs 235/35R20 front) — DO NOT rotate staggered tyres. Check your spec first. Uniform-size setups: rotate every 10,000 km.
Read guide →
🌧️Porsche 718 Wiper Replacement Malaysia
718 front: short flat blades. Replace every 6–12 months in Malaysia's UV and humidity. OEM Bosch Aerotwin or equivalent. Boxster soft-top: ensure water seal is intact to prevent pooling on hood.
Read guide →
🔍Porsche 718 O2 Sensor Malaysia
Wideband A/F sensor upstream + downstream cat monitor. DI carbon buildup causes lean fuel trim and O2 codes. Replace at 80,000–100,000 km or on fault code. RON97 fuel reduces sensor fouling vs RON95 ethanol blend.
Read guide →
🔩Porsche 718 Suspension Arms Malaysia
718: MacPherson front, multi-link rear. Control arm bushings wear at 80,000–100,000 km on Malaysian roads. PASM active dampers on GTS variants. Worn bushings cause steering wander and tyre edge wear. Inspect at 80k service.
Read guide →
🔬Porsche 718 Workshop Cases Malaysia — 4M Car Care
Real 718 cases: 982 Cayman 2.0L 63,000 km rough cold idle — carbon buildup confirmed via borescope. Walnut blast through intake manifold RM 1,100, idle immediately smoother. 982 Boxster S 2.5L 55,000 km PDK cold shudder — fluid never changed. Fluid flush + PIWIS re-adaptation RM 950, resolved. 982 Cayman GTS 4.0L 82,000 km rear diff whine — diff fluid dried out. Fluid change RM 380, noise eliminated.
Read guide →